C270   C 0 M M I S S I 0 N I N G   C H E C K   L I S T

1 PRE-LAUNCH CHECK:

1. ___ Shaft turns freely by hand, zinc collar installed if required.

2. ___ Check intake hoses and clamps.

3. ___ Check all through-hull fittings.

4. ___ Drain plugs tight, _ engine, muffler and exhaust line OK.

5. ___ Bottom clean, paint OK.

6. ___ Hull sides clean, gel coat OK.

7. ___ Decks clean, gel coat OK.

8. ___ Teak cleaned and oiled.

9. ___ Interior varnish OK.

10. ___ Cushions, carpeting, curtains, clean and in place.

11. ___ Forward berth conversion fits OK.

12. ___ Hatch lids present and fit OK.

13. ___ Lifelines and pulpits rigged and OK.

14. ___ Spreaders taped and drilled at base end, upper and intermediate shrouds
                wired to tip end and taped or boots installed.

15. ___ Standing rigging pinned to mast.

16. ___ Rigging lengths verified with check list in kit.

17. ___ Mast and boom inspected: cotter pins, sheaves, tangs, spreaders OK.

18. ___ Mast lights checked before mast stepped.

19. ___ Check over head for electrical wires which may interfere with the space
               required to raise the mast to its full upright position. If there are wires of any
               kind, anywhere near the boat, DO NOT RAISE THE MAST.   Move boat to
               another location away from any wires. Contact with wires can be fatal! .

20. ___ Masthead sheaves lubricated and rotate freely.

2 IN WATER CHECK:

2.1 ELECTRICAL:

1. ___ Electrical equipment operational:

                ___ Running ___ Cabin ___ Bow ___ Anchor

                ___ Spreaders ___ Pressure water

                ___ Macerator pump ___ Master

2. ___ Shore power outlet OK.

3. ___ Check battery switch #1 ___ #2 ___ OK.

4. ___ Check battery fluid level.

5. ___ Check battery terminal for tightness.

6. ___ Check battery tie-down straps.

.2.2 PLUMBING:

1. ___ No leaks at through hull fittings with seacocks open.

2. ___ Fill all water tanks.

3. ___ Check all water tanks at fittings, and vent for leaks.

4. ___ Test all faucets and foot pumps for leaks.


Back to Preface   Goto Page 2

Back to The Catalina 27/270 Main Page